Product ID:6400-6406 SERIES S/G POLY, 6400
MSDS Date:04/01/1991
FSC:8010
NIIN:00N056331
MSDS Number: BWNCK

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SO EL MONTE, CA 91733
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

2.1 @ 68F

CAS: 110-43-0

RTECS: MJ5075000

Fraction By Weight: 10%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA).

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM/200 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 3%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2.81 LB/GL

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HDCH, FATG, WEARINESS,
NAUS, VOMIT, DIZZ, STUPOR, DROW, DISTURBED VISION, COUGHING, AND
UNCON. SKIN:PRLNGD CONT CAN CAUSE MOD IRRIT, DEFAT, & DERM.
EYES:CAN CAUSE SEV IRRIT, REDNESS, TEARI NG, & BLURRED VISION. SKIN
ABSORP:MOD IRRIT, DEFAT, DERM, DRY SKIN, RASH. INGEST:BREATH SMELLS
OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SOLV. IRRIT OF LIPS & MOUTH, GI IRRIT,
NAUS, DIARR, DROW, LOSS OF CONSCIOUSNESS, STATE OF SHOCK, WEAK &
RAPID PULSE, COLD-PALE COMPLEXION. CHRONIC:MAY PRDCE LIVER & KIDNEY
DMG, PERSISTANT COU GH, BRAIN DMG & MAY EVEN CAUSE DEATH. NOTE:CA
EMPLOYERS USING CAL/OSHA-REGULATED CARCIN MUST REGISTER W/CAL/OSHA.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER AND KIDNEY
DISORDERS.

First Aid:EYES:FLUSH W/PLENTY OF WATER FOR 15 TO 30 MINS. GET MED ATTN.
SKIN:WASH EXPOS AREA W/MILD SOAP & WATER FOR 15 MINS. REMOVE
CONTAMD CLTHG. INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN
OXYG. IF B RTHG HAS STOPPED, GIVE ARTF RESP. GET MED ATTN.
INGEST:DO NOT INDUCE VOMIT. KEEP VICTIM WARM & SEEK IMMED MED
ATTENTION.

Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.1%
Upper Limits:11.4%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA W/FULL FACEPIECE
OPERATED IN PRESSURE DEMAND/OTHER POSITIVE PRESSURE MODES.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:FOLLOW INSTRUCTION TO PVNT HEALTH HAZARDS.
ELIMINATE ALL SOURCES OF IGNIT, ABSORB LIQUIDS IN ABSORBANT MATL &
PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS MAY BE HAZ WHEN EMPTIED, SINCE
EMPTIED CNTNRS MAY RETAIN PROD RESIDUALS (VAP, LIQ, AND/OR SOLIDS),
ALL PRECAUT GIVEN MUST BE OBSERVED.
Other Precautions:STORE @ ROOM TEMP AWAY FROM HEAT SOURCES, & HAVE LIDS
TIGHTLY CLSD. OVEREXPOS HAS APPARENTLY BEEN FOUND TO CAUSE
FOLLOWING EFTS IN LAB ANIMALS:LIVER ABNORM, KIDNEY DMG, LUNG DMG.
ALSO OVEREXPOS TO MAT L HAS BEEN SUGGESTED AS CAUSE (SUPDAT)

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED
NIOSH/MSHA JOINTLY APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA RESP
UNDER SPECIFIED CNDTNS. (SEE YOUR SFTY EQUIP SUPPLIER) (SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENT TO MAINTAIN EXPOSURE BELOW TLV'S.
Protective Gloves:POLYVINYL ALCOHOL COATED/POLYETHYLENE.
Eye Protection:ANSI APPRVD CHEM WORKER GOGGLES .
Other Protective Equipment:PREVENT RPTD/PRLNGD SKIN CONT W/GB PROT
HANDCREAM. WEAR IMPERVIOUS CLTHG & CHEM RESIST BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING REST ROOM,
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
OTHER PRECAUT:OF FOLLOWING EFTS IN HUMANS:CARDIAC ABNORM, LIVER ABNORM,
KIDNEY DMG, AND LUNG DMG. RESP PROT:ENGINEERING OR ADMIN CONTROLS
SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.

Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.6 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NON SOLUBLE
Appearance and Odor:VARIOUS COLORS WITH SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION MAY PRODUCE
CARBON DIOXIDE AND/OR CARBON MONOXIDE.

Waste Disposal Methods:RECYCLE LIQUIDS IF POSSIBLE, INCIN SOLIDS I/A/W
APPLIC REGULATIONS. AS LAST RESORT NEUTRALIZE & LANDFILL I/A/W
LOCAL, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.